Description Grain dryer
Grain dryers for drying rice and wheat primary , and after a little improvement can also be used to grab bake rapeseed and other crops. The primary components of grain dryers stoves , electric motors , axial fans and stacking racks and other components.
High-speed rotating impeller grain dryers operating femoral artery axial fan motor , so that the onset of the upper coal stove burning hot air inhaled by every wind deflector fan, and the fan sucked air from the lower plate of cold air across the gas mixture composition , through shelter after the dispersion tube into the stacker ( hot reflector effect so that the mixture is uniformly dispersed was even more ) , when the mixed gas through the valley of the shelves stacked layer side so that the appropriate temperature millet progress , take a lot of water vapor so that the side millet gradually dry. After the temperature of the mixture can cover the thermostat , the temperature conditioning plates open to different viewpoints conditioning . In order to make uniform drying millet , rice had often turning a spade .
 
 Grain dryer during the drying operation precautions
⑴ power , fan test , investigations of the direction of rotation , such as rendering rotation , immediately proofreading.
⑵ charge ; finalists will fall between rice and cereal shelf stacker , filling stops can be installed wet valley about 950 kg.
⑶ burning : first straw , wood shavings into the furnace like the midpoint of combustibles , and then participate in the wood, and wood burning than before participating in Anthracite blocks ( coal size of 3-4 cm, not too much ) , the moment should cover the closure temperature conditioning thermostat cover plate , power , start the motor , the fan impeller rotates in full after a few minutes the stove can burn brightly.
⑷ temperature control : primary open after temperature conditioning board to control the temperature of different viewpoints . Corresponds to a stable job is horizontal , as temperature is too low , you can move from the stove and fan to arrive.
⑸ rice flip : To make rice uniform drying , starting with the need to flip once every half hour , from 20-25 minutes to dry towards the end turning once . Its approach is to shovel the gap from the bottom shelf valley surrounded pierce , dishing out rice, then piled into the stacker top. Typically a group of rice can reach 6-7 times turning outstanding drying effect.
⑹ the material : Depending on experience and drying time , measure the material can be dried rice now . In order to facilitate the material can be carried out of the first frame enclosed valley , aside. Remove the rice move to other local , can be cooled by a little after storage.
⑺ 2-3 minutes before the material should eradicate slag, attend large amount of coal , so that when loading and unloading rice, stove will not subside.
⑻ Each unit shall be equipped with 2-3 people handle the stove and turning rice . Not from the dryer operator presents problems immediately shut down.
⑼ every fan should make before starting to see , around the motor and fan impeller debris found , it should be immediately eliminated. And pay attention to fire prevention, fire fighting supplies with demand .
⑽ attention to electrical safety , do not understand the power of common sense do not dismantling the motor , to avoid the risk of seizures .
⑾ based on the need to control the proper temperature for seeds should be strictly controlled below 45 ℃, grain should be controlled in the range of 60-70 ℃, temperature will increase grain fissuring , constitute more than broken , too low will affect drying power .
When ⑿ flip, flip to a large amount of each , every 3-4 spade shovel together , Trail back a week , so you can reach the inner and outer turning intentions.
 
Grain dryer unit skills and needs
① primary basis for an inventory list of all equipment , accessories, spare parts and supplies is not something entirely .
② device equipment site area of not less than 4,500 mm × 3,000 mm , all the equipment to move the device address.
③ first determine a good motor , axial fan orientation , and then bolt connection , then loaded on every hood and air hose .
④ Press the icon placement stove .
⑤ reflector plate placed in the stacker , stacker set into the inlet tube about 50 mm .
⑥ valley surrounded stacker rack set in the periphery .
 
Grain dryers in the process of applying for the protection and conservation
① When successive use , you should always check the machine is not working properly, in order to avoid the onset of trouble.
② often see V-belt tightness , when found too loose or too tight when the World Zhangci timely adjustments.
③ After the end use of the valley should be enclosed rack rack and stack it clean , dry , and then coated with a thin layer of paint to avoid rust, extend the use life.
④ often see the bearing housing grease cup is not a lack of oil , increased absence , replace if necessary.
 
Zhengzhou Dingli New Energy Technology Co., Ltd. specializes in the production of grain dryer, rice dryer, dryer wheat, corn drying machine, dryer peanut , rapeseed dryer, price concessions , quality assurance , welcomed by consumers , is the perfect choice, grain dryer welcome to inquire !